Abstract
In this study we investigated the potential effects of promoting bacterial activity on tailings from the Salobo iron-oxide copper-gold (IOCG) mine, Brazil. In particular we focussed on (1) the potential for mobilising additional Cu and (2) the effects of long-term storage on other metals. Unlike typical sulphide-ore tailings, the pH of the Salobo tailings is circumneutral and these tailings are dominated by Fe-bearing silicates and magnetite, with minor micrometre-scale encapsulated Cu-bearing sulphides. While these tailings do not produce acid mine drainage, an endemic strain of Acidithiobacillus ferrooxidans was isolated from the mine site. These bacteria were used in laboratory column leaching experiments of tailings material, which ran for up to 395 days, without the addition of ferrous iron. Bacteria-tailings interactions were typically maintained at a pH > 5, due to silicate-mediated pH buffering. This was eventually overcome after similar to 200 days by regular addition of acidic (pH 2.2) nutrient solution, as well as growth and acid generation by bacteria. Copper dissolution was not significantly enhanced by bacterial activity compared to abiotic control experiments while pH was >5. However, as the experiments were progressively acidified, additional Cu was mobilised in the biotic systems. The mineral alteration reactions produced abundant ferrihydrite precipitates within the tailings, which was enhanced by bacterial activity as the pH decreased. Adsorption of metal cations to these precipitates ensured that effluent solutions had only low levels (<0.5 mg/l) of dissolved trace metals such as As, Co, Pb, Zn, Se, Ni and Cr. These adsorption processes will strongly inhibit metal leaching from the tailings during long-term storage, as long as the iron oxidising bacteria are producing the requisite excess of ferrihydrite and the pH is >5. This case study shows that bacteriallymediated silicate weathering, in Fe(II)-bearing silicate rich tailings with only minor sulphides and Acidithiobucillus ferrooxidans can enhance the environmental stability of the tailings. (C) 2019 Elsevier B.V. All rights reserved.